| September 06, 2010 |
EPA, Navistar formally end litigation
EPA, CARB move ahead with further SCR reviews
By Jack Roberts
The legal battle Navistar had waged against the U.S. Environmental Protection Agency since March 2009 formally came to an end Aug. 16 when the two parties jointly filed to withdraw the lawsuit and a federal appeals court agreed. The dismissal of the case followed a settlement agreement executed in June whereby EPA agreed to hold a workshop or hearing to consider questions surrounding the use of selective catalytic reduction (SCR) to achieve the maximum levels of oxides of nitrogen (NOX) that EPA mandated for heavy-duty diesel engines beginning in January of this year.
Meanwhile, the California Air Resources Board already held a workshop in late July to make good on its own settlement with Navistar. Navistar, which relies on advanced exhaust gas recirculation (EGR) to comply with EPA’s 2010 regulations had sued both EPA and CARB, alleging, among other things, that the guidance given SCR-reliant engine makers would allow trucks using SCR to operate effectively for long periods of time without emissions controls if the SCR system were inoperable or if there was no diesel exhaust fluid (DEF) being injected into the system.
At the workshop in El Monte, California, Navistar representatives contended that independent test findings show new commercial vehicles that must contain DEF to meet federal NOx emissions standards continue to operate effectively when DEF is not present. At such times, Navistar said, the vehicles throw off levels of NOx as much as 10 times higher or more than when DEF is present.
The research cited by Navistar was conducted by EnSight, an independent environmental consulting firm, using two long-haul vehicles and one heavy-duty pickup, all of which used SCR. According to Navistar, EnSight’s research showed that when DEF was not present, there was little or no effect on the vehicles’ operations; this included long periods of time when the vehicles’ DEF tanks were empty or were refilled with water instead of urea. Navistar said one truck tested appeared to operate indefinitely with water and as a result without any functioning SCR NOx control, and that the truck had accumulated more than 13,000 miles with its SCR NOx emissions control turned off.
“What we are doing is looking at tightening up SCR certification requirements and clarifying the guidelines so that manufacturers know exactly how to meet them,” says Annette Hebert, chief of CARB’s mobile source operations division. Hebert said CARB’s initial focus is on the time, speeds and mileage SCR trucks can operate once the DEF tank is empty. “We also want to make certain the trucks cannot operate when they are out of spec – if water has been placed in the DEF tank or the SCR system has been tampered with in any way,” she says. “Our goal is to minimize the time and speed a truck can operate and create driver inducements that are stringent enough to encourage them to keep DEF in the system and avoid any performance penalties.”
John Mies, vice president of corporate communications for Mack Trucks and Volvo Trucks North America, responded strongly to Navistar’s claims. “Every single thing we’ve done – including the DEF inducement strategy – was done with the full cooperation, knowledge and approval of both the EPA and CARB,” said Mies.
“We learned a few weeks ago – not even six months after the implementation date for the new technology – that the regulations we followed in good faith were to be reconsidered,” Mies said. “And why? In large part because of concerns being raised by a single competitor. A competitor that says it is concerned about the environment, but whose U.S. ’10 engines will emit two-and-a-half times the 2010 NOx standard and are only certifiable with emissions credits.”
Mies openly questioned Navistar’s motivation in raising SCR compliance issues with EPA and CARB, noting that the “competitor” challenging current SCR standards:
• Said it was ready for the new standards, yet lobbied for a delay in implementation, and when that failed, resorted to lawsuits against the regulators;
• Apparently believes that most of its customers, and the trucking industry as a whole, are “hell-bent” on illegal circumvention of emissions controls; and
• Has been able to compete in the market this year only by selling thousands of pre-2010 engines.
“The fact is that a Mack or Volvo truck running at 0.2 grams is and will continue to be much better for the environment than a Navistar truck running at 0.5 grams – and no amount of changes to the inducement strategies will change that,” Mies said.
Allen countered that truck owners are paying a substantial price to comply with 2010 NOx requirements. “They, and the public, deserve to know that the new equipment they are purchasing actually works as promised to curb pollution,” he said. “It’s obvious, however, that these trucks can operate effectively without liquid urea, and that under these and other conditions, SCR NOx emission control is turned off. We’re calling on the EPA and CARB to assure that all vehicles, not just ours, work when they are supposed to be working.” EW
Using two long-haul vehicles and one heavy-duty pickup, the research Navistar cited found:
• When DEF was not present, there was little or no effect on the test vehicles’ operations.
• One test vehicle accumulated more than 13,000 miles with its SCR NOx emissions control turned off.
More From: Emissions
Do you want some tips to stay safe on the job site?
Equipment World has created an entire section devoted to safety.
Here are the most recent tips we've posted: